VILLAGER S1

100 gallons / 370 liters per hour 

1 gallon per minute x 60 minutes = 60 gallons / 222 liters

Filtration and Ultraviolet Light Disinfection

Stationary, Solar / Battery, 12-volt Powered Water Purification System for making Fresh Drinking Water in Remote Locations using water from Rivers and Lakes.

 

Cleaner and Safer Drinking Water from most any From Bore Holes or Tube Wells, Rivers, Lakes and Water Tanks or Fresh Water Sources

Stationary, Solar / Battery, 12-volt Powered Water Purification System for making Fresh Drinking Water in Remote Locations using water from Rivers and Lakes.

Aqua Sun engineered and designed the Villager – S1 System in 1994 and started manufacturing the system in 1995. Aqua Sun manufactures the Villager S1, Stationary, Wall Mount Solar Battery 12-volt Powered Water Purification Systems for Remote Applications. This system has the capabilities of producing cleaner and safer drinking water from almost any creek, stream, pond, well, lake or most any fresh water source at a volume production rate of 1 gallon (3.7 liters) per minute where water purification and electrical power are impractical or unattainable. The daily water production from the solar battery mode is up to 100+ gallons (370+ liters) per day. This System does not require any outside electrical power; nor is there a need for chemical additives.

Stationary Solar / Battery, 12-volt Powered Water Purification System for Emergency Relief Operations

This system is designed to be mounted into emergency vehicles such as a water tender or fire truck. It is wired directly into vehicles battery and the intake hose is for insertion into the apparatus water tank. All units additionally feature a sprayer to facilitate showering, misting (for lowering body temperature), and decontamination. The Villager S1 can be used for short term emergency use when water supply sources have become contaminated, a water tender or fire truck can be brought in and supply clean and safe drinking water to the local civilians until water surfaces can be brought back on line.  only If the local Public Health Department requires it, chlorine can be added to the cleaning process to add a residual disinfectant through the innovative Chlorinator Injector System.

This Villager S1, Solar Powered, 12-volt Water Purification Systems pulls the water from the source and through a  Sediment Filter to remove the sediment. The water is then pushed through a Carbon Block Polishing Filter that has the capabilities of removing Giardia and Cryptosporidium Cysts, Entamoeba and Toxoplasma Cysts, Schistosomiasis, Herbicides, Pesticides, Trihalomethanes (THMs), certain Volatile Organic Chemicals (VOCs), Chlorine and Chlorine By-Products, Sediment, Bad Taste, Odors, Color, Smell, and many other Harmful Chemicals and Contaminants down to a 0.5 micron. The polished filtered water is then channeled past an Ultraviolet Light Disinfecting Process that has the ability to kill Bacteria, Viruses, Typhoid Fever, Coliform, Dysentery, Cholera, Infectious Jaundice, Hepatitis and Influenza Virus, E-coli, Enteric Fever and many other unwanted microorganisms to a 99.999% purity.

 

We can ship our systems to almost anywhere in the world

Shipping sizes and weights for this system.

Villager S1 System; Box Size,  22 x 20 x 12 @ 30 lbs 

With Replacement Parts Kit;    24 x 20 x 18 @ 40 Lbs

We ship individually, pallets or ocean containers.

This System is approved for air shipments inside and outside the continental United States.

All water contact components carry a NSF Approval Rating and the ultraviolet light carries a Certificate of Analysis. 

 

This system comes in 2 different models: With and without water pressure.

Villager S1:    This system is for areas WITHOUT water pressure and no electrical power.

Villager A1:  Same system as above but for locations WITH 12 volt electrical power. 

We can design for your needs.

The filter and UV light manufacturers are members of the Water Quality Association.

Aqua Sun International is a registered DEPARTMENT OF DEFENSE CENTRAL CONTRACTOR, an approved UNITED NATIONS SUPPLIER, and a member of the AMERICAN SOLAR ENERGY SOCIETY (ASES)

 

Aqua Sun International located in Minden, Nevada U.S.A. engineered and designed the Villager line of solar water purification systems starting back in 1993 and is the original / only manufacturer of this system.

All designs, product literature and names are Copyrighted 1998 – 2010 and Trademarked.

 

Filtration Components:

 

SEDIMENT FILTER

Removes ground water sediment and protects the carbon block filter from premature clogging. Not washable.

APPROXIMATE FILTER LIFE EXPECTANCY depends on how dirty incoming water is or 1 year maximum.

 

 0.5 micron CARBON BLOCK  

Removes and reduces giardia lamblia and cryptosporidium cysts, volatile organic chemicals "VOC's" pesticides and herbicides, benzene, sediment, color, bad taste and odors such as hydrogen sulfide "rotten egg smell" and many other microorganisms down to a 0.5 micron. This Carbon Block Filter polishes the water crystal clear for refreshing good tasting water.

APPROXIMATE FILTER LIFE EXPECTANCY 10,000 gallons / 37,000 liters or one year of clear incoming water.

 

 ULTRAVIOLET DISINFECTING LAMP

Clean, safe and natural UV light rays have the ability to kill the bacteria and virus to 99.999 % purity without any harmful side effects much like chemical agents normally added to drinking water. The ultraviolet range is ideal for killing Micro-organisms such as E-coli, Coli form, Cholera, Legionnaires Disease, Hepatitis Virus, Typhoid Fever, Dysentery, Infectious Jaundice, Influenza, Enteric Fever and many other unwanted Microorganisms.

APPROXIMATE UV BULB LIFE EXPECTANCY 9000 hours, or approx 2 Years.

 

Specifications:

Turn-Key Systems, Built-in Flexibility 

Easy Set-Up, Instant Water Production 

1 gallon (3.7 liters) per minute approx. 

60 gallons (220 liters) per hour approx. 

100 gallons  (370 liters) max day. 

Water Source from Rivers, Lakes or Water Tanks

Pre–Plumbing and Pre-Wiring installed / connected

Ultraviolet Light (UV) Water Disinfection System

System Size  16” wide x 18" long x 6" deep @ 30 Lbs.

Solar Panel:  17" long x 14" wide x 2” thick

Battery / System Running Time =  100 minutes.

10 ft Inlet and Outlet flexible hose connections

Rated Water Pressure: 20 PSI minimum / 65 PSI maximum.

Ultraviolet Lamp Output: 16,000 microwatt seconds per centimeter squared and carries a Certificate of Analysis.

NSF and FDA APPROVED on filtration and water contact components. 

 

Standard Features:

Size: System Dimensions;  16” wide x 18" long x 6" deep

Output Watts: 

• Ultraviolet Light only; 10 Watts / 0.84 amps per hour
• Self Priming Water Pump; 1.8 amps max per hour depending on head

Weight Empty:   approx. 30 lbs. 

Inlet Connection: ¾ “Female Standard Hose Threaded Port / Swivel. 10 feet long

Outlet Connections: ¾ “Male Standard Hose Threaded Ports. 7 feet long

Rated Water Pressure:   20 PSI minimum / 65 PSI maximum

Ultraviolet Lamp Output: 16,000 microwatt seconds per centimeter squared and carries a Certificate of Analysis

Hoses, electrical cords and all misc. fittings included with system 

NSF and FDA APPROVED on filtration and water contact components

Filter and UV Replacement Parts Filter Kits at a discounted available

During Emergency Responses, the Villager provides fast, flexible access to emergency water

The Villager S1 supports Emergency Relief Camps being pre-positioned and then brought out quickly for hurricanes, tornadoes, ice storms, earthquakes, etc

The Villager S1 provides fresh water for personal showering, hydration, decontamination, fire personnel re-hab, medical needs, evacuation and transport support

Easily Adaptable to ice machines, kitchen facilities and food preparation, laundry support, dish washing machines, etc and supports shelters housing several hundred people

  

Options (extra fees apply):

U.S. Voltage to 12 volt; 120 volt to 12 volt electrical power converter.   $300.00  

International Voltage to 12 volt;   220 volt 50 Hz. Uses a 220 volt 50 Hz to a 120 volt Power Step Down Transformer then the above 120 volt to 12 volt converter.  $300.00  

Lamp Out Circuit;  Different UV System with Solenoid Valve,  will not operate all water flow if UV light is not ON.  $400.00

 

Non Profit and Distributor Pricing  available.

For pricing, more information, or to place an order,
call us at (775) 783-8566

Or click here for other ways to contact us

 

Here are some things people have said about the Villager Systems

 

To:   Aqua Sun International

Subject: back from Haiti

Hi Greg,

Returned last week from Haiti. I have a letter written to St. Andrew’s who financed the water purifiers for the 200 children at the orphanage and I will send you a copy. It was quite exciting to hear Sr. Leona (the principal) talk about the decrease in absences at school due to the illness because of the clean water. It was a huge problem before. She had tears in her eyes as she talked about the children.

We have another challenge. We send children who are really sick and need longer term care to Sister of Charity which is one of Mother Theresa’s Missions. These sisters are unbelievable. They help anyone who is sick! They boil water for everyone in the complex. There were 65 children when we were there. Mostly babies and small ones. We have a church trying to take this challenge. We visited the grounds twice. We have a church interested in taking the challenge of funding. ?

Please advice as to what you think we would again purchase the battery in Haiti now that we have that source.

Thanks for the parts. Perfect!

Thank you. Friends of the children

Cindy Schuetz

 

To: Aqua Sun International

Subject: Water Purifier –Vessels of Mercy Intl.

Dear Greg,

You should be very proud of developing such a wonderful product that can help so many lives around the world, especially in Honduras. I have traveled in 43 countries over the past 16 years and seen many water purifiers in the field, and I would have to say that is the best one yet, excellent product!!!!!!

Thanks again.

Bev. Gibson

Vessels of Mercy Intl.

Next >