VILLAGER S6 - 4

1000 gallons / 3,700 liters per day

Filtration and Ultraviolet Light Disinfection
Stationary Solar Powered Water Purification System for Remote Applications using water from Rivers and Lakes WITHOUT water pressure.

 

Cleaner and Safer Drinking Water from most any From Bore Holes or Tube Wells, Rivers, Lakes and Water Tanks or Fresh Water Sources

Aqua Sun manufactures the Villager – S6 - 4 System. This system is a wall mount system and is completely automatic that can take its water from a river, lake, well, or holding tank systems and produce approx 6 gallons / 22 liters per minute x 60 minutes = 360 gallons / 1,322 liters per hour x 3 hours = 1,000 gallons / 3,700 liters in a 3 hour period. This system will use a solar / battery powered 12-volt system to supply its electrical power needs. Whenever the sun is shining, the solar system will always be recharging the battery, even when the water treatment system is working. This system comes as a turn-key package. It is designed for easy installation as all of the wiring is pre wired and plumbing is pre-plumbed and all that needs to be done is hang the water treatment system on the wall in a convenient location. Plumbing in and out of the water treatment system is easy with 10 foot inlet female hose and 10 foot outlet male hose pre-plumbed into system. The Controller Panel will need to be located with-in 3 ft of the Water Treatment System preferably in between the 2 systems. The Battery Wire is prewired and will need to have the Positive (+) and Negative (-) wires connected to the battery. Mount the solar panel in a sunny location and within 25 feet of the system. Attach the solar wires to the panel that are already prewired into the control box. Install Filters and UV Lamp and the system is ready for operation. It is simple and easy to install the Villager S6-4 Solar / Battery Powered Water Purification System.

 This Villager S6-4 / Solar Battery / 12-volt Powered Water Purification Systems pulls the water from the source and through a Washable / Reusable Sediment Filter which removes large particles, sticks and leaves and then through Sediment Filter to remove the sediment. The water is then pushed through a Carbon Block Polishing Filter that has the capabilities of removing Giardia and Cryptosporidium Cysts, Entamoeba and Toxoplasma Cysts, Schistosomiasis, Herbicides, Pesticides, Trihalomethanes (THMs), certain Volatile Organic Chemicals (VOCs), Chlorine and Chlorine By-Products, Sediment, Bad Taste, Odors, Color, Smell, and many other Harmful Chemicals and Contaminants down to a 0.5 micron. The polished filtered water is then channeled past an Ultraviolet Light Disinfecting Process that has the ability to kill Bacteria, Viruses, Typhoid Fever, Coliform, Dysentery, Cholera, Infectious Jaundice, Hepatitis and Influenza Virus, E-coli, Enteric Fever and many other unwanted microorganisms to a 99.999% purity.

 

We can ship our systems to almost anywhere in the world

Shipping sizes and weights for this system.

Without Replacement Parts Kit;  

2 boxes  36”x 20” x 14 @ 40 lbs.

1 box  30” x 14” x 12” @ 20 lbs.

1 box  3” x 50” x 24” @ 25 lbs.

With Replacement Parts Kit; add 2 boxes  23” x 16” x 10” long  @ 40 Lbs   

This does not include battery due to weight and shipping hassles, Purchase in Country. We can send requirement specifications.      

We ship individually, pallets or ocean containers.

This System is approved for air shipments inside and outside the continental United States.

All water contact components carry a NSF Approval Rating and the ultraviolet light carries a Certificate of Analysis.

This system comes in 2 different models: With and without water pressure.

Villager S6-4:    This system is for areas WITHOUT water pressure and not electrical power.

Villager S12-4:  Same system as above but for locations WITH a minimum of 20-30 PSI water pressure. Maximum 75 psi.  

We can design for your needs.

The filter and UV light manufacturers are members of the Water Quality Association.

Aqua Sun International is a registered DEPARTMENT OF DEFENSE CENTRAL CONTRACTOR, an approved UNITED NATIONS SUPPLIER, and a member of the AMERICAN SOLAR ENERGY SOCIETY (ASES)

 

Aqua Sun International located in Minden, Nevada U.S.A. engineered and designed the Villager line of solar water purification systems starting back in 1993 and is the original / only manufacturer of this system.

All designs, product literature and names are Copyrighted 1998 – 2010 and Trademarked.

 

Filtration Components:

WASHABLE / REUSABLE  Pre-FILTER

Removes river and lake water particles such as leaves, twigs, sediment and protects the sediment pre-filter from premature clogging. This filter is easily washed and cleaned when clogged.

APPROXIMATE FILTER LIFE EXPECTANCY depends on how dirty incoming water is or 1 year maximum.

 

SEDIMENT FILTER

Removes ground water sediment and protects the carbon block filter from premature clogging. Not washable.

APPROXIMATE FILTER LIFE EXPECTANCY depends on how dirty incoming water is or 1 year maximum.

 

 0.5 micron CARBON BLOCK  

Removes and reduces giardia lamblia and cryptosporidium cysts, volatile organic chemicals "VOC's" pesticides and herbicides, benzene, sediment, color, bad taste and odors such as hydrogen sulfide "rotten egg smell" and many other microorganisms down to a 0.5 micron. This Carbon Block Filter polishes the water crystal clear for refreshing good tasting water.

APPROXIMATE FILTER LIFE EXPECTANCY 150,000 gallons / 555,000 liters or one year of clear incoming water.

 

 ULTRAVIOLET DISINFECTING LAMP

Clean, safe and natural UV light rays have the ability to kill the bacteria and virus to 99.999 % purity without any harmful side effects much like chemical agents normally added to drinking water. The ultraviolet range is ideal for killing Micro-organisms such as E-coli, Coli form, Cholera, Legionnaires Disease, Hepatitis Virus, Typhoid Fever, Dysentery, Infectious Jaundice, Influenza, Enteric Fever and many other unwanted Microorganisms.

APPROXIMATE UV BULB LIFE EXPECTANCY 9000 hours, or approx 2 Years.

 

Specifications:

Turn-Key Systems, Built-in Flexibility 

Easy Set-Up, Instant Water Production 

6 gallons (22 liters) per minute approx. 

360 gallons (1,332 liters) per hour approx. 

1,000 gallons  (3,700 liters) per day approx. 

Water Source from Rivers, Lakes or Water Tanks  

Pre–Plumbing and Pre-Wiring installed / connected 

0.5 micron Carbon Block Filtration

Ultraviolet Light (UV) Water Disinfection System 

12- volt Photovoltaic Solar Panel  /  Battery Powered 

Control Panel:  16" tall x 9" wide x 7 deep. 15 lbs. 

Solar Panel:  47" L x 21" W x 2" D x 20 lbs. 

Battery: 12 volt - 13"L x 7"W x 10"D x 75 lbs.  

Battery / System Running Time =  3 hrs max. 

Battery Charge Storage Life = 1+ Year 

10 ft Inlet and Outlet flexible hose connections

Rated Water Pressure:   20 PSI minimum / 65 PSI maximum.

Ultraviolet Lamp Output: 16,000 microwatt seconds per centimeter squared and carries a Certificate of Analysis.

NSF and FDA APPROVED on filtration and water contact components.

 

Standard Features:

Size: Filters Housings and Mounting Bracket,  30" long x 18 wide x 9" deep,  2 pcs

Size: Control Panel,   28" long x 9" wide x 7" deep, 15 Lbs.

Output Watts: 

• Ultraviolet Light only; 22 Watts / 1.89 amps per hour
• Self Priming Water Pump; 15 amps max per hour depending on head

Weight Empty:   approx. 80 lbs. Shipping Weight Not including Battery. Battery 75 lbs.

Inlet Connection: ¾ “Female Standard Hose Threaded Port / Swivel. 10 feet long

Outlet Connections: ¾ “Male Standard Hose Threaded Ports. 10 feet long

Rated Water Pressure:   20 PSI minimum / 65 PSI maximum

Ultraviolet Lamp Output: 16,000 microwatt seconds per centimeter squared and carries a Certificate of Analysis

Hoses, electrical cords and all misc. fittings included with system 

NSF and FDA APPROVED on filtration and water contact components

Filter and UV Replacement Parts Filter Kits at a discounted available

  

Options (extra fees apply):

U.S. Voltage to 12 volt; 120 volt to 12 volt electrical power converter.   $300.00  

International Voltage to 12 volt;   220 volt 50 Hz. Uses a 220 volt 50 Hz to a 120 volt Power Step Down Transformer then the above 120 volt to 12 volt converter.  $300.00  

Lamp Out Circuit;  Different UV System with Solenoid Valve,  will not operate all water flow if UV light is not ON.  $500.00

 

Non Profit and Distributor Pricing  available.

For pricing, more information, or to place an order,
call us at (775) 783-8566

Or click here for other ways to contact us

 

Here are some things people have said about the Villager S6-4

 

To: Aqua Sun International

Dominican Republic Mission

Villager System

 Hi Greg,

 Thanks so much for the quick reply.

The system installation of the Villager System was in the village of "Mena" in the Dominican Republic near the Haitian border and all went very well.

 I am gathering information for a similar system to install in a village in the Democratic Republic of Congo. Last year, there was a Cholera outbreak and many people died due to dehydration.  In this remote area, Unicef and WHO are not able to reach the people quick enough and there is often loss of life.

 So, I appreciate this information.

After we go over all of the information, we will be meeting with the leader of the mission to see if this is feasible to do in Africa.

 Thanks,

 Melody Ball

 

To: Aqua Sun International

Subject:  THANK YOU

 Greg:  We recently attended a conference/summit in Indiana with the Parish Twinning Program.  You name and company was mentioned by our group as often as we could.  Seems there is a high demand for your equipment and related materials.  We told them how impressed we have been, not only with your equipment, but also with your service and advice.  We talked with some ladies from Milwaukee and they are sooooo happy with the equipment they purchased from you. 

 I will write more at a later date, however wanted to give you a heads up in the event you hear from some of the groups we talked to.  We will also forward your web site and email address to the head quarters of the Twinning group. 

 We want to THANK YOU again for all your help and assistance.

 Thomas Reichert

Sec. Friends of the Children

< Prev		Next >